Product ID:BUILT SOAP, POWDERED, TFTC-95-HM-7911
MSDS Date:09/13/1995
FSC:7930
NIIN:00-926-5262
MSDS Number: CBTRS

GURTLER CHEMICALS, INC

15475 SOUTH LASALLE STREET
SOUTH HOLLAND, IL 60473
US

Emergency Phone: 708-331-2550

Info Phone: 708-331-2550

Preparer: MICHAEL A JACOBS

Cage: 0CA58

GURTLER CHEMICALS INC

SOUTH HOLLAND, IL 60473 US

Telephone: 708-331-2550

Cage: 0CA58

SILICIC ACID, DISODIUM SALT

CAS: 6834-92-0

RTECS: VV9275000

Fraction By Weight: 20-40%

SODIUM CARBONATE (NUISANCE DUST PARTICLES)

CAS: 497-19-8

RTECS: VZ4050000

Fraction By Weight: 10-30%

ACGIH TLV: 10 MG/M3

SODIUM TALLOWATES

CAS: 61789-66-0

Fraction By Weight: >50.0%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY CAUSE SEVERE IRRITATION OF
THE EYES, INCLUDING CORNEAL OPACITIES. DUST IS IRRITATING TO THE
SKIN, MUCOUS MEMBRANES, AND UPPER RESPIRATORY TRACT. CHRONIC: MAY
CAUSE INFLAMATION OF THE MUCOUS MEMBRANES IN THE RESPIRATORY TRACT
ANDOF THE SKIN.
Explanation of Carcinogenicity:NA
Medical Cond Aggravated by Exposure:NA

First Aid:EYES: FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. SEE AN OPTHALMOLOGIST IF IRRITATION PERSISTS. SKIN: WASH
WITH PLENTY OF WATER. IF IRRITATION OCCURS AND PERSISTS, OBTAIN
MEDICAL ATTE NTION. INGESTION: DRINK A GLASS OF WATER OR MILK.

Flash Point:NA
Autoignition Temp:Autoignition Temp Text:NA
Lower Limits:NA
Upper Limits:NA
Extinguishing Media:WATER, FOAM, DRY CHEMICALS
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:SPONTANEOUS HEATING, MODERATE

Spill Release Procedures:SWEEP UP AS MUCH AS POSSIBLE FOR SALVAGE OR
DISPOSAL. WASH AWAY RESIDUE WITH WATER.
Neutralizing Agent:NONE

Handling and Storage Precautions:DO NOT STORE CLOSE TO ACIDS. MINIMIZE
THE FREE FALL WHEN HANDLING TO MINIMIZE THE DUST GENERATED.
Other Precautions:WEAR EYE PROTECTION AND NIOSH/MSHA APPROVED DUST
RESPIRATOR TO PREVENT IRRITATION WHERE EXCESSIVE DUST IS PRESENT.

Respiratory Protection:WEAR DUST RESPIRATOR IF NUISANCE DUST TLV OF 10
MG/M3 IS EXCEEDED OR DISCOMFORT IS PRESENT.
Ventilation:GENERAL VENTILATION - LOCAL EXHAUST IF NEEDED FOR DUST
CONTROL.
Protective Gloves:GENERAL PURPOSE
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:FULL COVER CLOTHING
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NEGLIGIBLE
Vapor Density:NA
Spec Gravity:0.79 (WATER=1)
pH: 12.0
Viscosity:NA
Evaporation Rate & Reference:NA
Solubility in Water:>10%
Appearance and Odor:OFF WHITE POWDER WITH SOAP ODOR
Percent Volatiles by Volume:NA

Stability Indicator/Materials to Avoid:YES
CONTACT WITH ACIDS RELEASES LARGE VOLUMES OF CARBON DIOXIDE GAS AND
HEAT. STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:CONTACT WITH ACIDS EXCEPT UNDER CONTROLLED
CONDITIONS.
Hazardous Decomposition Products:NONE

Waste Disposal Methods:IF MATERIAL CANNOT BE SALVAGED, THE PREFERRED
METHOD OF DISPOSAL IS IN A SECURE CHEMICAL LAND FILL IN ACCORDANCE
WITH ALL FEDERAL, STATE & LOCAL ENVIRONMENTAL REGULATIONS. EMPTY
CONTAINERS MAY BE INCI NERATED OR DISCARDED AS GENERAL TRASH.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.